Door squeaks and creaks — hinges and boot cover fixes

Tags: #door · #squeak · #window · #rattle

Door hinges: doors creak/squeak when opening. Fix: (1) clean the hinge with WD-40 to remove moisture and corrosion; (2) apply a proper lubricant — silicone grease works better than the dry graphite lubricant included with some door-limiter kits, which dries out in heat. Specific recommendation: Molykote 111 silicone lubricant (rated -40 to +260°C), which works well with door limiters ¹²³⁴⁵.

Door boot cover (обшивка): squeaking/creaking from the door boot trim can be fixed by (1) removing the trim panel and applying silicone spray to the contact points, or (2) using an anti-squeak compound ("антискрип"), sold on Ozon. Both fixes confirmed effective by community members ⁶⁷⁸⁹.

Door glass rattle at high volume: the driver's-side window glass rattles/vibrates at high music volume, creating an annoying noise — affects multiple X80 owners. Possible causes: window-seal degradation or glass mounting tolerances. Temporary workaround: drop the window down slightly, which reduces vibration. A more permanent fix involves door-panel disassembly and applying sound-deadening material, but this may only partially resolve the issue ^1011121314.

Rattle from poor-quality door trim sound damping: a common rattling sound in the cabin at idle or low speed comes from poor-quality sound damping material installed inside the door panels, which vibrates. Diagnostic: pressing the door trim inward while the engine idles stops the noise temporarily, confirming the trim is the source. Fix: remove the door trim, clean off the old adhesive, and apply proper anti-squeak adhesive tape along panel edges or under the rubber trim seals ^1516171819. Note: a separate report also links interior rattle/vibration felt in the pedal/clutch area at idle or in traffic to worn engine mounts — replacing the mounts eliminated that particular vibration and noise entirely ¹⁸.

Media

Dry graphite lubricant from the factory door limiter kit

Applied silicone-based lubricant on door hinge/limiter

Related pages

• Side mirror assembly — folding motor failure
• Wiper system — normal behavior and malfunctions
• Door check strap/limiter — sourcing
• Door replacement — cost and fitment issues
• Door limiter worn bushings cause loose doors

Sources

This page is compiled from 19 community messages. Every fact carries a numbered reference to its original author and message.

Last updated: 2026-07-24